Product ID:E-35 CHILLER
MSDS Date:01/01/1987
FSC:5820
NIIN:00-229-1068
MSDS Number: BRFMR

BIO-TEK INC.

4680 ALVARADO CANYON ROAD 575
SAN DIEGO, CA 92120-4304
US

Emergency Phone: 619-286-1786

Info Phone: 619-286-1786

Cage: 59557

BIO-TEK INC.

CARSON CITY, NV 89706 US

Telephone: 619-233-7229

Cage: 59557

DICHLORODIFLUOROMETHANE (SARA III)

CAS: 75-71-8

RTECS: PA8200000

Fraction By Weight: 100%

OSHA PEL 1000 PPM

ACGIH TLV: 1000 PPM; 9192

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES/SKIN:IRRITATION WITH
DELAYED EFFECTS. INHALATION:IRRITATION TO THROAT AND LUNGS,
HEADACHE, DIZZINESS, DROWSINESS
INCOORDINATION,UNCONSCIOUSNESS,FOLLOWED BY DEATH IN SEVERE CASES.
ASPIRATIO N MAY OCCUR FROM INGESTION. GASTROINTESTINAL SYSTEM
DISCOMFORT MAY DEVELOP, FOLLOWED BY VOMITING AND DIARRHEA.
Explanation of Carcinogenicity:NONE OF THE CHEMICALS IN THIS PRODUCT IS
LISTED BY IARC, NTP OR OSHA AS A CARCINOGEN.
Effects of Overexposure:IRRITATION OF EYES/SKIN. NAUSEA AND VOMITING.
VOMITING MAY OCCUR SPONTANEOUSLY. DO NOT ALLOW VOMITUS TO BE
BREATHED INTOLUNGS (WILL CAUSE CHEMICAL PNEUMONITUS, PULMONARY
EDEMA/ HEMORRHAGE. BLUISH SKIN , GAGGING, COUGHING, AND LABORED
BREATHING. ANESTHETIC EFFECT IN HIGH CONCENTRATIONS.
Medical Cond Aggravated by Exposure:SKIN DISORDERS.

First Aid:EYE:IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR 15 MINUTES.
GET MEDICAL ATTENTION. SKIN:WASH WITH SOAP AND WATER. WASH SOILED
CLOTHING. INHALATION:REMOVE TO FRESH AIR. GIVE MOUTH-TO-MOUTH
RESUSCITATION IF NEEDED. KEEP VICTIM WARM AND GIVE OXYGEN IF
NEEDED. INGESTION:DO NOT INDUCE VOMITING. GIVE CONSCIOUS VICTIM
LOTS OF WATER. SEEK MEDICAL ATTENTION.

Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL AS APPROPRIATE FOR SURROUNDINGS.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. EVACUATE AREA. COOL
FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS. PRESSURIZED AEROSOL
CONTAINERS MAY RUPTURE OR EXPLODE.

Spill Release Procedures:VACATE AREA, WEAR PROTECTIVE EQUIPMENT AND
VENTILATE AREA IMMMEDIATELY. STOP LEAK IF POSSIBLE. SPILL WILL
EVAPORATE.

Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA AWAY FROM SOURCES OF IGNITION. KEEP CONTAINER CLOSED. PROTECT
FROM PHYSICAL DAMAGE. KEEP FROM FREEZING.
Other Precautions:DO NOT PUNCTURE, INCINERATE OR STORE CONTAINERS ABOVE
120F. NOTE TO PHYSICIANS: EXPOSURE BRINGS INCREASED RISK OF
ELICITING CARDIAC DYSRYTHMIAS. DO NOT USE EPINEPHRINE EXCEPT AS A
LAST RESORT.

Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXPOSURES BELOW PEL (TLV), USE NIOSH APPROVED RESPIRATOR AS PER
CURRENT 29 CFR 1910.134, INSTRUCTIONS/WARNINGS AND NIOSH-RESPIRATOR
SELECTION. SCBA MAY BE N EEDED IN CONFINED AREAS.
Ventilation:MECHANICAL (GENERAL) VENTILATION IS USUALLY ADEQUATE.
Protective Gloves:RUBBER OR PVC
Eye Protection:NO CONTACTS. SAFETY GLASSES/FACE SHIELD
Other Protective Equipment:SAFETY SHOWER AND EYE BATH. INDUSTRIAL TYPE
WORK CLOTHING AND APRON AS REQUIRED TO AVOID PROLONGED OR REPEATED
CONTACT.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING OR DRINKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
MFR DOES NOT HAVE MSDS, CONTRACT TOO OLD. INFORMATION PRESENTED HEREIN
IS ACCURATE AND RELIABLE TO THE BEST OF OUR KNOWLEDGE AND BELIEF
BUT IS NOT GUARANTEED TO BE SO. IT IS THE USER'S RESPONSIBILITY TO
TAKE ALL SAFETY PRECAUTIONS AS MAY BENECESSARY. WE HEREBY DISCLAIM
ALL LIABILITY WITH RESPECT TO IT'S USE.

HCC:V2
Boiling Pt:B.P. Text:-22F,-30C
Vapor Pres:80 PSIG
Vapor Density:4.2 AIR=1
Spec Gravity:1.31
Evaporation Rate & Reference:>1 (N-BUTYL ACETATE=1)
Solubility in Water:0.028%
Appearance and Odor:COLORLESS, LIQUIFIED GAS; SLIGHT ETHEREAL ODOR
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, ALKALI AND ALKALINE EARTH METALS, POWDERED AL,
ZN, BE, OR MG.
Stability Condition to Avoid:HEAT (>120F) , OPEN FLAMES AND OTHER
SOURCES OF IGNITION
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY PRODUCE
HYDROGEN CHLORIDE,HYDROGEN FLUORIDE,PHOSGENE, OTHER CARBONYL
HALIDES

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE AND LOCAL REGULATIONS. MANUFACTURER INDICATES USING
A SPECIALIST DISPOSAL COMPANY. DISPOSAL OF CONTAINERS WITH CONTENTS
WILL BE A LAND-BANNE D HAZARDOUS WASTE (CODE F002)

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.